A8 Parts Forum  

Go Back   A8 Parts Forum > A8 D2 > D2 - Interior

D2 - Interior Seats, dashboards, plastics, ventilation everything inside the cabin

Reply
 
Thread Tools Display Modes
  #1  
Old 9th November 2014, 09:48 PM
HPsauce HPsauce is offline
Senior Member
 
Join Date: Sep 2011
Location: Chilterns, almost over HS2!
Posts: 8,366
Default Where on Earth does it all come from!

I thought I was on top of my various drains issues, having had a fair few I know what signs to look for etc. and how to deal with them.

My last trip out in the S8 (before today) was to Goodwood for the V-power breakfast meet last Sunday. Now that was a ridiculously wet day, but using the car for a couple of local journeys in the afternoon in the sun all seemed OK.

Since then it's been parked (outside) unused and there has been a fair bit of rain.............
(But I hadn't noticed any significant telltale signs of condensation on the glass)

Got in this morning and reversed out, rear end downhill and SLOOSH!
The NSR footwell had a good inch of water above the carpet, and the rear centre vents were spraying water everywhere, mostly from the nearside one.
Didn't have time to do anything, so just had to live with huge sloshes of water coming out over our feet at every corner, though I did go round a few fairly aggressively to get out as much as I could.

Cleared out as best I could at our destination (100 miles away) and am now home drying out what I can. I have checked the scuttle drains and they're totally clear and dry when I looked - pour water in and it comes straight though under the car.

So it's apparently blocked aircon condenser drains (again!) so I'll clear those out ASAP on a fine day.
But I'm mystified as to how so much water could have got into them in just a week when the car is parked so no condensate from the aircon.
The wooden footboard over the electrics panel is wet from the bottom up, so it's presumably not water getting in through Botangs hole.

Any thoughts people?
__________________
2003 D2 FL S8. Irish Green Pearl/Beige. Solar sunroof, auto-dim mirrors, electric rear seat functions, ski hatch retrofit; extended leather. Aftermarket DVB-T, reversing camera and full XCarlink (Bluetooth etc.).
2016 Volvo V40 T5 Cross Country (4WD) with ALL the toys including adaptive cruise etc. etc. Osmium Grey with Blonde/Charcoal leather interior. Polestar performance "optimisation". (A much rarer model than a D2 S8 by the way!) Oh, and a brand new engine at just under 30,000 miles on the factory one!
Finally: gone, but not forgotten.....
1998 D2 PF S8. AgateGrey/Platinum. Every option (I think) except electric rear seats, tiptronic steering wheel, ski hatch, towbar & dimming door mirrors.
e.g. Cruise control, NavPlus/TV, Bose, GSM, Xenons, Solar roof, Parking sensors, Alcantara/leather everywhere of course. (internal dimming mirror added later)
1998 (very early) Ford Focus 1.8 Zetec; ABS/TCS, Heated screen/mirrors, Aircon, Auto-dim mirror, Leather, Trip computer, Cruise control, OEM Ford SatNav with CD changer.
And before that a lot of Rover 800s, a few oddities, a lovely Triumph Dolomite 1850HL with Overdrive and way back in my schooldays an Austin Seven aka Mini 850!

Last edited by HPsauce; 9th November 2014 at 09:51 PM.
Reply With Quote
  #2  
Old 9th November 2014, 09:55 PM
Reffro Reffro is offline
Senior Member
 
Join Date: Mar 2009
Location: Bushey, Herts
Posts: 421
Default

I had similar trouble. I can't remember where exactly but there was a crack in the intake for the aircon if I remember correctly. Rain water was entering in directly through it. I'm sorry to say it took a large amount of work to correct.
Reply With Quote
  #3  
Old 9th November 2014, 10:07 PM
HPsauce HPsauce is offline
Senior Member
 
Join Date: Sep 2011
Location: Chilterns, almost over HS2!
Posts: 8,366
Default

I guess I'll clear the drains and then put tubes/bottles on the outlets from the condenser tray, hose the windscreen and see what happens.

Funny thing is, in recent weeks I've had more occasions of small seeds (look like birch) coming out of the vents at times.

Not from anywhere I've been so maybe a legacy that are slowly working through the HVAC and ending up blocking the drains.
__________________
2003 D2 FL S8. Irish Green Pearl/Beige. Solar sunroof, auto-dim mirrors, electric rear seat functions, ski hatch retrofit; extended leather. Aftermarket DVB-T, reversing camera and full XCarlink (Bluetooth etc.).
2016 Volvo V40 T5 Cross Country (4WD) with ALL the toys including adaptive cruise etc. etc. Osmium Grey with Blonde/Charcoal leather interior. Polestar performance "optimisation". (A much rarer model than a D2 S8 by the way!) Oh, and a brand new engine at just under 30,000 miles on the factory one!
Finally: gone, but not forgotten.....
1998 D2 PF S8. AgateGrey/Platinum. Every option (I think) except electric rear seats, tiptronic steering wheel, ski hatch, towbar & dimming door mirrors.
e.g. Cruise control, NavPlus/TV, Bose, GSM, Xenons, Solar roof, Parking sensors, Alcantara/leather everywhere of course. (internal dimming mirror added later)
1998 (very early) Ford Focus 1.8 Zetec; ABS/TCS, Heated screen/mirrors, Aircon, Auto-dim mirror, Leather, Trip computer, Cruise control, OEM Ford SatNav with CD changer.
And before that a lot of Rover 800s, a few oddities, a lovely Triumph Dolomite 1850HL with Overdrive and way back in my schooldays an Austin Seven aka Mini 850!

Last edited by HPsauce; 9th November 2014 at 10:09 PM.
Reply With Quote
  #4  
Old 10th November 2014, 08:33 AM
David's8's Avatar
David's8 David's8 is offline
Senior Member
 
Join Date: Jan 2012
Location: Helensburgh, Scotland
Posts: 3,506
Default

These type of seeds are a real problem for me too. They get everywhere in the car. I have a Silver Birch, two huge Lime trees and a Copper Beech in the garden/road next to the house and every autumn is a battle. Big leaves are not a problem but these little blighters get into everthing.
__________________
2002 D2 S8 – Ming Blue, Valcona leather, Vavona wood insert, solar sunroof (to be fitted), Heated rear seats, extended leather pack, 18” Avus, ski hatch, Bose, auto dim rear view mirror, rear blind.
Reply With Quote
  #5  
Old 10th November 2014, 10:40 AM
HPsauce HPsauce is offline
Senior Member
 
Join Date: Sep 2011
Location: Chilterns, almost over HS2!
Posts: 8,366
Default

The nearest tree to where I park is an Oak. No acorns have been found anywhere in the car. There is a silver birch in the area, but it's between 2 back gardens at least 50 yards away and my house is in between it and the car.

As the sun is out I'm letting a combination of car greenhouse effect and solar sunroof ventilation do the drying work for now. I'll have a look at the drains a bit later.
__________________
2003 D2 FL S8. Irish Green Pearl/Beige. Solar sunroof, auto-dim mirrors, electric rear seat functions, ski hatch retrofit; extended leather. Aftermarket DVB-T, reversing camera and full XCarlink (Bluetooth etc.).
2016 Volvo V40 T5 Cross Country (4WD) with ALL the toys including adaptive cruise etc. etc. Osmium Grey with Blonde/Charcoal leather interior. Polestar performance "optimisation". (A much rarer model than a D2 S8 by the way!) Oh, and a brand new engine at just under 30,000 miles on the factory one!
Finally: gone, but not forgotten.....
1998 D2 PF S8. AgateGrey/Platinum. Every option (I think) except electric rear seats, tiptronic steering wheel, ski hatch, towbar & dimming door mirrors.
e.g. Cruise control, NavPlus/TV, Bose, GSM, Xenons, Solar roof, Parking sensors, Alcantara/leather everywhere of course. (internal dimming mirror added later)
1998 (very early) Ford Focus 1.8 Zetec; ABS/TCS, Heated screen/mirrors, Aircon, Auto-dim mirror, Leather, Trip computer, Cruise control, OEM Ford SatNav with CD changer.
And before that a lot of Rover 800s, a few oddities, a lovely Triumph Dolomite 1850HL with Overdrive and way back in my schooldays an Austin Seven aka Mini 850!
Reply With Quote
  #6  
Old 10th November 2014, 01:48 PM
HPsauce HPsauce is offline
Senior Member
 
Join Date: Sep 2011
Location: Chilterns, almost over HS2!
Posts: 8,366
Default

Interesting. I took the nearside drain out - easier to get at and as my drive has a slight slope it's the "downhill" one.
A good 700ml of slightly-coloured water came out of the condenser tray.

I then took the orange drain pipe indoors to inspect. It looked ok at first glance, but was definitely blocked.
The exit tip was clear, I'd trimmed it back a bit previously so the slots were open about 3mm anyway. I think the blockage was in the "horizontal" pipe section, it blew out very easily.

I collected the bits. It was plant debris, all quite small only 1mm or 2mm along/across. About half was unidentifiable black woody/seedy material and the rest was those blasted seeds!

It obviously settles in the tubes as water dribbles through and slowly builds up until blocked. I can't think of any obvious way to stop that so I guess it will just have to be a regular maintenance job.

Still need to work out how the excess water/debris arrives there though.
__________________
2003 D2 FL S8. Irish Green Pearl/Beige. Solar sunroof, auto-dim mirrors, electric rear seat functions, ski hatch retrofit; extended leather. Aftermarket DVB-T, reversing camera and full XCarlink (Bluetooth etc.).
2016 Volvo V40 T5 Cross Country (4WD) with ALL the toys including adaptive cruise etc. etc. Osmium Grey with Blonde/Charcoal leather interior. Polestar performance "optimisation". (A much rarer model than a D2 S8 by the way!) Oh, and a brand new engine at just under 30,000 miles on the factory one!
Finally: gone, but not forgotten.....
1998 D2 PF S8. AgateGrey/Platinum. Every option (I think) except electric rear seats, tiptronic steering wheel, ski hatch, towbar & dimming door mirrors.
e.g. Cruise control, NavPlus/TV, Bose, GSM, Xenons, Solar roof, Parking sensors, Alcantara/leather everywhere of course. (internal dimming mirror added later)
1998 (very early) Ford Focus 1.8 Zetec; ABS/TCS, Heated screen/mirrors, Aircon, Auto-dim mirror, Leather, Trip computer, Cruise control, OEM Ford SatNav with CD changer.
And before that a lot of Rover 800s, a few oddities, a lovely Triumph Dolomite 1850HL with Overdrive and way back in my schooldays an Austin Seven aka Mini 850!
Reply With Quote
  #7  
Old 10th November 2014, 02:14 PM
HPsauce HPsauce is offline
Senior Member
 
Join Date: Sep 2011
Location: Chilterns, almost over HS2!
Posts: 8,366
Default

Quote:
Originally Posted by HPsauce View Post
small seeds (look like birch) coming out of the vents at times.

Not from anywhere I've been so maybe a legacy that are slowly working through the HVAC and ending up blocking the drains.
Having had a look under the bonnet and taken the access panels off in the scuttle/wiper area I think it's just a legacy of earlier owners.
There are (were ) little lumps of debris, including those seeds, absolutely everywhere so there's probably a fair number inside the HVAC system as well.
I might look at putting some finer mesh on the grille over the main air intake in case the filters are somehow being bypassed.

I'll clear out the drivers side drain at some future date; I need to go in there soon anyway to finish off my various RNS add-ons.
__________________
2003 D2 FL S8. Irish Green Pearl/Beige. Solar sunroof, auto-dim mirrors, electric rear seat functions, ski hatch retrofit; extended leather. Aftermarket DVB-T, reversing camera and full XCarlink (Bluetooth etc.).
2016 Volvo V40 T5 Cross Country (4WD) with ALL the toys including adaptive cruise etc. etc. Osmium Grey with Blonde/Charcoal leather interior. Polestar performance "optimisation". (A much rarer model than a D2 S8 by the way!) Oh, and a brand new engine at just under 30,000 miles on the factory one!
Finally: gone, but not forgotten.....
1998 D2 PF S8. AgateGrey/Platinum. Every option (I think) except electric rear seats, tiptronic steering wheel, ski hatch, towbar & dimming door mirrors.
e.g. Cruise control, NavPlus/TV, Bose, GSM, Xenons, Solar roof, Parking sensors, Alcantara/leather everywhere of course. (internal dimming mirror added later)
1998 (very early) Ford Focus 1.8 Zetec; ABS/TCS, Heated screen/mirrors, Aircon, Auto-dim mirror, Leather, Trip computer, Cruise control, OEM Ford SatNav with CD changer.
And before that a lot of Rover 800s, a few oddities, a lovely Triumph Dolomite 1850HL with Overdrive and way back in my schooldays an Austin Seven aka Mini 850!

Last edited by HPsauce; 10th November 2014 at 02:19 PM.
Reply With Quote
  #8  
Old 10th November 2014, 02:52 PM
David's8's Avatar
David's8 David's8 is offline
Senior Member
 
Join Date: Jan 2012
Location: Helensburgh, Scotland
Posts: 3,506
Default

I find that a wet VAX machine is the right tool for clearing all that crud out. I have done this fairly regularly due to the local conditions here (i.e. raining frequently and HUGE amounts of leaf / seed debris and (tempting fate here ) I havent had a problem since the first time I had a wet carpet problem about 2 years ago.
__________________
2002 D2 S8 – Ming Blue, Valcona leather, Vavona wood insert, solar sunroof (to be fitted), Heated rear seats, extended leather pack, 18” Avus, ski hatch, Bose, auto dim rear view mirror, rear blind.
Reply With Quote
  #9  
Old 10th November 2014, 07:21 PM
HPsauce HPsauce is offline
Senior Member
 
Join Date: Sep 2011
Location: Chilterns, almost over HS2!
Posts: 8,366
Default

This is what I found inside the passenger side drain, I expect a fair bit of it came inside originally when the scuttle drains were blocked:
Attached Thumbnails
Click image for larger version

Name:	DrainCrud.jpg
Views:	320
Size:	26.8 KB
ID:	9449  
__________________
2003 D2 FL S8. Irish Green Pearl/Beige. Solar sunroof, auto-dim mirrors, electric rear seat functions, ski hatch retrofit; extended leather. Aftermarket DVB-T, reversing camera and full XCarlink (Bluetooth etc.).
2016 Volvo V40 T5 Cross Country (4WD) with ALL the toys including adaptive cruise etc. etc. Osmium Grey with Blonde/Charcoal leather interior. Polestar performance "optimisation". (A much rarer model than a D2 S8 by the way!) Oh, and a brand new engine at just under 30,000 miles on the factory one!
Finally: gone, but not forgotten.....
1998 D2 PF S8. AgateGrey/Platinum. Every option (I think) except electric rear seats, tiptronic steering wheel, ski hatch, towbar & dimming door mirrors.
e.g. Cruise control, NavPlus/TV, Bose, GSM, Xenons, Solar roof, Parking sensors, Alcantara/leather everywhere of course. (internal dimming mirror added later)
1998 (very early) Ford Focus 1.8 Zetec; ABS/TCS, Heated screen/mirrors, Aircon, Auto-dim mirror, Leather, Trip computer, Cruise control, OEM Ford SatNav with CD changer.
And before that a lot of Rover 800s, a few oddities, a lovely Triumph Dolomite 1850HL with Overdrive and way back in my schooldays an Austin Seven aka Mini 850!
Reply With Quote
  #10  
Old 10th November 2014, 10:52 PM
Architex_mA8tey's Avatar
Architex_mA8tey Architex_mA8tey is offline
Moderator
 
Join Date: Jan 2009
Location: London/Oxford/Swindon
Posts: 7,648
Default

you might want to look at THIS THREAD and also THIS ONE for how Guy resolved his when it did the same as yours into the rear
__________________

Confidence is the feeling you have before you know better . . . .
Audi A8 D2 3.7 Quattro Sport 1999 FL - Melange
2nd Place Winner - A8-Freunde Annual German Meet 2012 at Edersee
20" x 9" Bentley GTC Wheels with 385mm W12 Front Discs & Bentley Caliper Covers, Front Lowered on Coilovers, Xenons, Combined DRLs and LED Foglights to modified OEM front fog lamp position, Alcantara/Leather, Full Black Alcantara headlining + pillars and blind shelf, Bespoke Flat Bottomed Sports Steering Wheel, Dark Myrtle Wood, Autodim Mirrors, Bose, Blinds, Digital TV, Ski Hatch, Modified rear exhaust section for extra V8 Burble
Audi S8 D2 Final Edition 2002, Avus Silver with Red Leather Interior
Tiptronic with Sport mode button, Sony rear entertainment package, Bose sound system, Audi Navigation Plus, 20 inch Final Edition alloys, Full Cat Back Stainless Milltek exhaust, giving a great V8 burble
Audi A8L D2 4.2 Petrol with LPG - Ebony Black
Audi A8L D4 FL 4.0T Petrol twin turbo - Havana Black
Audi A2 1.6 FSi Sport - Dolphin Grey with Votex body kit and Red Leather Interior
and some other A8's A8L's and Mercs
Reply With Quote
Reply

Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off

Forum Jump


All times are GMT. The time now is 10:50 PM.


Powered by vBulletin® Version 3.8.0
Copyright ©2000 - 2024, Jelsoft Enterprises Ltd.