S8 D2 glass sunroof adjustment??

[mark_le_b]

Hello all

The rear of my glass sunroof is sitting low - ie not flush with the roof - any idea if it can be adjusted to fit properly flush
It opens and closes ok - but have had a small leak and this and blocked drains may not have helped, so hope there is away to make it fit better!

Thanks

Mark

[David's8]

Yes it can. I'll dig out the reference which is in the Tech Dump.

[David's8]

Its in the Manual on General Body Assembly Exterior page 125.

[mark_le_b]

Thanks for that

Mark

[The_Laird]

But it's a 2 man job isn't it David? :)

[mark_le_b]

One inside, one outside to check level??

[David's8]

One inside, one outside to check level??

Exactly. The requirement to have the leading edge ~0-1mm below and the trailing edge ~0-1mm above the roof level requires the outside person to hold the sunroof in place /check the levels as the person inside tightens the screws. +++

[mark_le_b]

Thanks for that, will give it a go - just have to fathom hoe to get the headliner off the sunroof to expose the bolts

[The_Laird]

Thanks for that, will give it a go - just have to fathom hoe to get the headliner off the sunroof to expose the bolts

Open the sunroof about half way. Pop the 2 plastic clips at the front and then push the headlining backwards.

[mark_le_b]

great, thanks