|
D3 - Axles, Brakes, Suspension and Steering Brakes, Springs, shocks, steering racks, steering columns, suspension arms, wheel hubs etc. |
|
Thread Tools | Display Modes |
#1
|
|||
|
|||
Squealing noise
My pass side brakes seem to squeak, not sure if it front or rear but when I apply the brakes it stops. Worried if it might be callipers? I am sure this only happened after I let my friend borrow the car
__________________
A8L 3.0 TDI sport executive 2014. Audi A2 1.4 petrol 2002 SOLD. Audi A8L 4.2TDI Silver 2006 Seat Ibiza 1.4tdi Eco 2008 Silver (£0 Tax)sold NO VCDS rely on Neeldub |
#2
|
|||
|
|||
Could be a small stone/chipping stuck between caliper and brake disc ?
|
#3
|
|||
|
|||
Car is in the garage at present for checkup. The rear pass brake was getting hot and their was a slight burning smell dreading if it’s calliper. Any ideas guys what the best option is if it s the calliper? I see they do the repair kits. Has anyone repaired theirs or can someone recommend a decent refurb place.
Thanks
__________________
A8L 3.0 TDI sport executive 2014. Audi A2 1.4 petrol 2002 SOLD. Audi A8L 4.2TDI Silver 2006 Seat Ibiza 1.4tdi Eco 2008 Silver (£0 Tax)sold NO VCDS rely on Neeldub |
#4
|
|||
|
|||
Don’t dread a calliper, a refurb with motor is ~£200 form carparts4less with a refundable surcharge when you send your old one back, there are many more expensive parts than this
|
#5
|
|||
|
|||
__________________
A8L 3.0 TDI sport executive 2014. Audi A2 1.4 petrol 2002 SOLD. Audi A8L 4.2TDI Silver 2006 Seat Ibiza 1.4tdi Eco 2008 Silver (£0 Tax)sold NO VCDS rely on Neeldub |
#6
|
|||
|
|||
Garage checked it over. They could not find the fault but noticed the disc is reddish in colour. Now I was planning on possibly refurbishing my two rear callipers. Need guidance howto take them off. Would I need VCDS to release them? Also anybody heard of biggred refurbishing company?
__________________
A8L 3.0 TDI sport executive 2014. Audi A2 1.4 petrol 2002 SOLD. Audi A8L 4.2TDI Silver 2006 Seat Ibiza 1.4tdi Eco 2008 Silver (£0 Tax)sold NO VCDS rely on Neeldub |
#7
|
|||
|
|||
I've used Biggred before. Funnily enough, they did the calipers on Big Red and made quite a nice job of them
|
#8
|
|||
|
|||
Spoke to Bigred MJ, they don’t do my ones as they are electric! they said Co called Shaftec in Midlands. Anyone know these Co? Also please someone advice me if I need VCDS to remove calliper? In London all the damn garages have limited space and only want you to buy a new one so they can just straight replace! I want to refurbish my ones. What say you?
__________________
A8L 3.0 TDI sport executive 2014. Audi A2 1.4 petrol 2002 SOLD. Audi A8L 4.2TDI Silver 2006 Seat Ibiza 1.4tdi Eco 2008 Silver (£0 Tax)sold NO VCDS rely on Neeldub |
#9
|
||||
|
||||
VCDS not required for front but will be required to remove the back to release the EPB
__________________
2008 (facelift) S8 with B&O, ACC, glass sunroof, reversing camera, front and rear heated seats, ceramic brakes, homelink, electric side and rear blinds, ski load through, heated fan washer jets, remote boot closing, de-flapped manifold, fridge, umbrella holder |
#10
|
||||
|
||||
I used the Carista Bluetooth plug in dongle thingy, with there app. On my phone to open and close the motor mechanism.
I purchased a piston and seal kit off ebay to refurbish the caliper. After much cleaning of the caliper I set about fitting the seals and pistons. Ended up reusing the original pistons in the end. The new ones were not chamfered enough to push through the seals without tearing them. They were budweg pistons, I would try a different brand next time. You do need to give the seal groove a thorough cleaning out. How the motor mechanism works is very simple, nothing to be worried about.
__________________
2006 A8 d3 4.2tdi sport stoke-on-trent. |
|
|